Mazda 3 Service Manual: Hood Disassembly/Assembly
Except Mazdaspeed3
1. Disassemble in the order indicated in the table.
|
1 |
Weather strip parting seal |
|
2 |
Weather strip shroud seal |
|
3 |
Fasteners A |
|
4 |
Fasteners B |
|
5 |
Fasteners C |
|
6 |
Hood insulator |
|
7 |
Hood component |
2. Assemble in the reverse order of disassembly.
Mazdaspeed3
1. Disassemble in the order indicated in the table.
|
1 |
Weather strip parting seal |
|
2 |
Weather strip shroud seal |
|
3 |
Nut A |
|
4 |
Fasteners B |
|
5 |
Charge air cooler duct |
|
6 |
Fasteners C |
|
7 |
Hood insulator |
|
8 |
Nut D |
|
9 |
Charge air cooler duct cover |
|
10 |
Grommet |
|
11 |
Hood component |
2. Assemble in the reverse order of disassembly.
Hood Adjustment
Gap Adjustment
1. Verify that the gap between the hood and the body is within the specification.
Standard clearance
a: -2.8—0.8 mm {-0.11—0.03 in}
b: –1.2—1.2 mm {–0.047—0.0.47 ...
Hood Latch And Release Lever Removal/Installation
Hood latch
1. Open the hood.
2. Disconnect the negative battery cable..
3. Disconnect the hood latch switch connector. (vehicles with theft-deterrent
system)
4. Remove the bolts.
5. ...
Other materials:
Rear Speaker Removal/Installation
4SD
1. Disconnect the negative battery cable..
2. Remove the following parts:
a. Rear seat cushion.
b. Rear scuff plate.
c. Tire house trim.
d. C-pillar trim.
e. Rear package trim.
3. Remove the screw.
4. Disconnect the connector.
5. Remove the rear speaker.
6. Install in th ...
Inside Trunk Release Lever
(4-Door)
Your vehicle is equipped with an inside
trunk release lever that provides a means
of escape for children and adults in the
event they become locked inside the trunk.
No matter how careful adults might be
with keys and locking their cars, parents
should be aware that children may be
tempted ...
Coupler Component Removal/Installation [Fw6 A EL]
WARNING:
A hot transaxle and ATF can cause severe burns. Turn off the engine and wait
until they are cool.
Always wear protective eye wear when using the air compressor. If the air
compressor is used, any particles of dirt or soiling could spatter and get into
the eyes.
...
