WARNING:
Fuel is very flammable liquid. If fuel spills or leaks from the pressurized fuel system, it will cause serious injury or death and facility breakage. Fuel can also irritate skin and eyes. To prevent this, always complete the “Fuel Line Safety Procedure”, while referring to the “BEFORE SERVICE PRECAUTION”.
A person charged with static electricity could cause a fire or explosion, resulting in death or serious injury. Before draining fuel, make sure to discharge static electricity by touching the vehicle body.
Except for Mexico
1. Complete the “BEFORE SERVICE PRECAUTION”..
2. Disconnect the negative battery cable..
3. Remove the fuel pump unit..
4. Siphon the fuel from the fuel tank.
NOTE:
The non-return valve is integrated in the fuel tank.
The non-return valve is normally closed by the spring force.
5. Verify that the non-return valve is closed.
If the non-return valve is stuck open and does not open even when pulled up by a finger, replace the fuel tank..
Mexico
1. Complete the “BEFORE SERVICE PRECAUTION”..
2. Remove the non-return valve..
3. Verify that the non-return valve is closed.
If malfunction, replace the non-return valve..
4. Verify that the non-return valve is not stuck open and does not open even when pulled up by a finger.
If malfunction, replace the non-return valve..
Combination Switch Removal/Installation
CAUTION:
Handling the air bag module improperly can accidentally deploy the air bag
module, which may seriously injure you. Read the air bag system service warnings
and cautions before handling the air bag module..
1. Switch the ignition to off.
2. Disconnect the negative batte ...
Rear Bumper Removal/Installation
4SD
1. Disconnect the negative battery cable..
2. Remove the rear combination light..
3. Remove the fastener A and screw B.
4. Remove the rear splash shield..
5. Remove the screws C.
6. Remove the bolts D.
7. Affix the protective tape to the position shown in the figure.
...
Oil Pump Removal/Installation [Mzr 2.3 Disi Turbo]
WARNING:
Hot engines and engine oil can cause severe burns. Turn off the engine and
wait until it and the engine oil have cooled.
A vehicle that is lifted but not securely supported on safety stands is dangerous.
It can slip or fall, causing death or serious injury. Never work ...